Comparation Study of The Use Naftalena From Coal Tar Waste with Camper Naphtalene As Concrete Admixture

  • Sumarno Agung Faculty of Engineering, University Mercu Buana Jakarta, Indonesia (ID)
  • Syafwandi Syafwandi Faculty of Engineering, University Mercu Buana Jakarta, Indonesia (ID)
  • Adelia Rizky Fatmawati Faculty of Engineering, University Mercu Buana Jakarta, Indonesia (ID)
  • Sumiyati Sumiyati Faculty of Administration, University Mercu Buana Jakarta, Indonesia (ID)
Keywords: Naphthalene coal tar, naphthalene camphor, compressive strength

Viewed = 145 time(s)

Abstract

Concrete is a mixture of Portland cement or other hydraulic cement, fine aggregate, coarse aggregate, and water, with or without additives (admixture). The naphthalene superplasticizer used comes from the distillation of coal tar and a little from the rest of petroleum, but there is also camphor naphthalene. Where camphor grains contain 250-500 mg of naphthalene. Naphthalene is mostly produced from coal tar distillation, and a little from the rest of the fractionation of petroleum, by the molecular formula (C10H8) and in the form of two unified benzene rings. This compound is volatile, volatile even in the form of solids. The vapor produced is flammable. The purpose of this study was to determine the effect of the use of naphthalene from coal tar waste with camphor naphthalene as concrete admixture, and determine the effect of naphthalene from coal tar waste with camphor naphthalene on concrete toughness, density, water absorption, of concrete compressive strength. It is expected that the use of naphthalene can reduce the use of cement, and reduce water use. But it does not reduce the strength of the concrete so as to reduce costs in making concrete. The variations in the use of camphor naphthalene and coal tar naphthalene are 20%, 30%, 40%.



Downloads

Download data is not yet available.

References

Badan Standarisasi Nasional. Persyaratan beton struktural untuk bangunan gedung (SNI 2847: 2013). Jakarta: Standar Nasional Indonesia, 2013.

Simatupang, Partogi H.; Sir, Tri Mw; Kurniaty, Anna S. Pengaruh Substitusi Parsial Semen Dengan Abu Terbang Terhadap Karakteristik Teknis Beton. Jurnal Teknik Sipil, 2016, 5.2: 139-148

Nadia, Nadia; Aprilianti, Seti. Analisis Pengaruh Beton Dengan Bahan Admixture Naphtalene Dan Polycarboxilate Terhadap Kuat Tekan Beton Normal. Konstruksia, 2012, 3.2

Prasetyo, Lukito. Pengaruh Variasi Gradasi Limbah Beton Sebagai Bahan Pengganti Agregat Terhadap Kuat Tekan. In: Prosiding Sentra (Seminar Teknologi Dan Rekayasa). 2019. P. 52-55

Sarwono, D., Legowo, S. J., & Raspati, A. (2015). Karakteristik Tar Hasil Destilasi Tempurung KelapaDengan Modifikasi PenambahanAsbuton EmulsiDitinjauDari Spesifikasi Aspal Produk Pertamina. Matriks Teknik Sipil, 3(3).

Prasetyo, E. (2015). Unjuk Kerja Lpg Engine-Generator Set Menggunakan Syn-Gas Gasifikasi Batubara Dengan Variasi Derajat Pengapian Dan Tekanan Masuk Syn-Gas (Doctoral dissertation, Institut Teknologi Sepuluh Nopember).

Published
2020-11-16
Section
Articles
How to Cite
Agung, S., Syafwandi, S., Fatmawati, A. R., & Sumiyati, S. (2020). Comparation Study of The Use Naftalena From Coal Tar Waste with Camper Naphtalene As Concrete Admixture. Journal of Applied Science, Engineering, Technology, and Education, 2(2), 165-173. https://doi.org/10.35877/454RI.asci2160